發布時間：2019-06-06 01:45

【摘要】：再生瀝青混合料由溫度比較高的新料與加熱溫度比較低的舊混合料混合而成�；厥諡r青混合料的溫度低或摻入比例大則再生混合料的出料溫度低,攤鋪后可能造成碾壓溫度達不到要求,影響壓實度的后果。為了解決這一問題可降低回收料比例,或者提高回收料或新料溫度,但兩種方法均存在不足。在瀝青或?yàn)r青混合料中加入溫拌劑是解決上述問題較好的技術方法之一。論文首先對老化瀝青溫拌再生機理展開研究,通過室內模擬老化試驗,模擬老化瀝青+再生劑+溫拌劑的再生過程。通過對老化瀝青再生過程中瀝青組分、化學組成、微觀結構及宏觀性能變化的研究,分析總結了瀝青老化及加溫拌劑的再生機理。在室內模擬相關試驗分析的基礎上,對實際路面回收料中的老化瀝青進行試驗研究。室內模擬的老化與實際路面的老化存在不同,對回收料中的老化瀝青溫拌再生過程進行試驗分析,并與室內模擬研究成果進行對比,總結完善了老化瀝青溫拌再生機理。以上述研究和廠拌熱再生為基礎,對加入溫拌劑的廠拌溫再生混合料性能進行試驗研究。對比了廠拌熱再生和溫拌再生混合料路用性能的差異。溫拌再生混合料的性能能夠滿足瀝青混合料技術性能要求,具有比廠拌熱再生混合料更低的拌和溫度,溫拌劑的加入解決了提高回收料比例或降低加熱溫度的問題,并且溫拌再生混合料具有更好的低溫性能。研究成果對溫拌再生的實際應用具有指導意義。
[Abstract]:Recycled asphalt mixture is composed of new material with higher temperature and old mixture with low heating temperature. If the temperature of recycled asphalt mixture is low or the proportion of recycled asphalt mixture is large, the discharge temperature of recycled mixture is low, which may cause the rolling temperature to not meet the requirements after paving, which may affect the compaction degree. In order to solve this problem, the proportion of recycled materials can be reduced or the temperature of recycled materials or new materials can be increased, but both methods have shortcomings. Adding warm mixture to asphalt or asphalt mixture is one of the better technical methods to solve the above problems. In this paper, the mechanism of warm mixing and regeneration of aged asphalt is studied, and the regeneration process of warm mixing agent of aging asphalt is simulated by simulated aging test in laboratory. Based on the study of asphalt composition, chemical composition, microstructure and macroscopic properties in the process of asphalt regeneration, the regeneration mechanism of asphalt aging and heating mixture was analyzed and summarized. Based on the experimental analysis of laboratory simulation, the aging asphalt in the actual pavement recovery material is studied. The aging of indoor simulation is different from that of actual pavement. The process of warm mixing and recycling of aged asphalt in recycled materials is tested and analyzed, and the results are compared with the results of indoor simulation, and the mechanism of warm mixing and recycling of aged asphalt is summarized and improved. Based on the above research and the thermal regeneration of plant mixing, the properties of the mixture with warm mixing agent were studied. The differences of road performance between hot and warm mixture were compared. The performance of warm mix recycled mixture can meet the technical performance requirements of asphalt mixture, and has lower mixing temperature than hot recycled mixture in factory mixing. The addition of warm mixing agent solves the problem of increasing the proportion of recycled materials or reducing the heating temperature. And warm mix recycled mixture has better low temperature performance. The research results have guiding significance for the practical application of warm mix regeneration.
【學位授予單位】：哈爾濱工業大學
【學位級別】：碩士
【學位授予年份】：2017
【分類號】：U414

【參考文獻】

相關期刊論文 前10條

1 龐琦;孫國強;孫大權;;FT-IR在瀝青熱氧老化研究中的應用[J];石油瀝青;2016年03期

2 張笑;;溫拌再生瀝青混合料性能研究[J];公路工程;2016年03期

3 秦永春;黃頌昌;徐劍;王隨原;;廠拌溫再生瀝青混合料中新舊瀝青的融合性研究[J];公路交通科技;2015年12期

4 楊軍;王瀟婷;龔明輝;陳先華;焦麗亞;;瀝青原子力顯微鏡微觀圖像的特征分析[J];石油學報(石油加工);2015年05期

5 盧寶忠;;基于原子力顯微鏡技術的瀝青微觀力學特性研究[J];交通建設與管理;2015年08期

6 李新陽;黃剛;王俐棟;;溫拌瀝青混合料技術綜述[J];石油瀝青;2013年01期

7 劉永貴;凌劍興;張繼森;吳超凡;;Evotherm溫拌瀝青混合料性能試驗研究[J];公路工程;2013年01期

8 黃明;王鵬;李彥偉;黃衛東;;溫拌再生瀝青混合料關鍵技術研究與性能評價[J];公路;2012年10期

9 朱文天;;國外瀝青路面再生概況[J];交通世界(建養.機械);2012年06期

10 孫吉書;肖田;楊春風;靳燦章;;溫拌再生瀝青混合料的路用性能研究[J];重慶交通大學學報(自然科學版);2011年02期

相關博士學位論文 前1條

1 龐凌;瀝青紫外光老化特性研究[D];武漢理工大學;2008年

相關碩士學位論文 前3條

1 佘龍;瀝青熱再生劑的研制及其應用[D];重慶交通大學;2016年

2 于澤民;溫拌再生劑對瀝青和瀝青混合料路用性能影響研究[D];大連理工大學;2015年

3 張葆琳;基于紅外光譜的瀝青結構表征研究[D];武漢理工大學;2014年

，

本文編號：2493978